Preview

Advanced Engineering Research (Rostov-on-Don)

Advanced search

To problem of hydrogen embrittlement of steel at droplet impingement erosion

https://doi.org/10.23947/1992-5980-2017-17-2-56-69

Abstract

Introduction. The work is devoted to the problem of the hydrogen saturation of steel parts skin at their high-speed impacts with a water-drop flow. A hypothesis of the water molecules dissociation at high-speed drop impacts was suggested in a number of papers. This hypothesis was confirmed by some experimental data. The effect of this dissociation is hydrogen embrittlement of the metal surface layer. The work objective is the calculation and experimental verification of the given mechanism of the erosion destruction of the steel surface. Materials and Methods. Energy equations of various ways of the water molecules dissociation are considered for the calculation-analytical estimates. The Tate and van der Waals equations are used with allowance for the change in the phase states of water at impact. Experimental data are obtained on the basis of spectral analysis using visible monochromatic (qualitative analysis) and infrared (quantitative analysis) emissions. Research Results. An improved calculation apparatus is proposed to determine the energy level of the water molecules dissociation and free hydrogen release with account for the compressibility of water at achievable impact speeds. The results of spectral studies of bubble tracks formed on the experimental steel samples under the bench erosion tests are presented. The spectral analysis shows that the tracks are composed of air bubbles. Free hydrogen is not detected in them. Discussion and Conclusions. The calculated and experimental data obtained in this paper do not give grounds for confirming the hypothesis of hydrogen dissociation under the water-drop impacts with a steel surface in the impact velocity range of 200-600 m / s. Therefore, the mechanism of hydrogen embrittlement, apparently, should be excluded from the number of additive components of the droplet impingement erosive wear.

About the Authors

Oleg V. Kudryakov
Don State Technical University
Russian Federation


Valery N. Varavka
Don State Technical University
Russian Federation


Vladimir A. Irkha
Don State Technical University
Russian Federation


Irina V. Moiseeva
Platov South-Russian State Polytechnic University
Russian Federation


References

1. Varavka, V.N., Kudryakov, O.V., Ryzhenkov, A.V. Multilayered Nanocomposite Coatings for Anti-Erosive Protection. Chapter 5. Piezoelectrics and Nanomaterials: Fundamentals, Developments and Applications. I.A. Parinov, ed. New- York: Nova Science Publishers, 2015, pp. 105–132.

2. Varavka, V.N., et al. Modelirovanie ustalostnoy komponenty protsessa degradatsii metallicheskoy poverkhnosti v usloviyakh vozdeystviya dvukhfaznogo potoka. [Modeling of fatigue component of metal surface degradation process under conditions of two- phase flow.] Integrirovannye vibrovolnovye tekhnologii v mashinostroenii, metalloobrabotke i drugikh otraslyakh: sb. tr. Mezhdunar. nauch. simpoz. [Integrated vibro-wave technologies in machine building, metalworking and other industries: Proc. Int. Acad. Symposium.] Rostov-on-Don: DSTU Publ. Centre, 2015, pp. 325–330 (in Russian).

3. Kudryakov, O.V., et al. Osobennosti protsessov degradatsii poverkhnosti metallicheskikh materialov pri zhidkokapel'nom udarnom vozdeystvii. [Features of surface degradation of metallic material surfaces under liquid droplet impact.] Materialy i tekhnologii XXI veka: sb. statey KhIV Mezhdunar. nauch.-tekhn. konf. [Materials and technologies of the XXI century: Proc. Int. Sci.-Tech. Conf.] Penza: Privolzhskiy Dom znaniy, 2016, pp. 27–31 (in Russian).

4. Matyushenko, V.Ya. Iznosostoykost' navodorozhennykh metallov. [Wear resistance of hydrogen-charged metals.] Issledovanie vodorodnogo iznosa. [Investigation of hydrogen wear.] Moscow: Nauka, 1977, pp. 24–27 (in Russian).

5. Margulis, М.А. Osnovy zvukokhimii (khimicheskie reaktsii v akusticheskikh polyakh). [Fundamentals of sound chemistry (chemical reactions in acoustic fields).] Moscow: Vysshaya shkola, 1984, 272 p. (in Russian).

6. Zavilopulo, A.N., Chipev, F.F., Shpenik, O.B. Ionizatsiya molekul azota, kisloroda, vody i dvuokisi ugleroda elektronnym udarom vblizi poroga. [Ionization of nitrogen, oxygen, water, and carbon dioxide molecules by near-threshold electron impact.] Technical Physics, 2005, vol. 50, iss. 4, pp. 402-407 (in Russian).

7. Mezhdunarodnaya baza dannykh atomnykh i molekulyarnykh konstant NIST. [NIST International database of atomic and molecular constants.] U. S. Secretary of Commerce on behalf of the United States of America; NIST Standard Reference Database. Available at: http://www.webbook.nist.gov (accessed: 15.01.16) (in Russian).

8. Chizhov, A.V. Chislennoe issledovanie vysokoskorostnogo vzaimodeystviya kapli zhidkosti s pregradoy : avtoref. dis ... kand. tekh. nauk. [Numerical investigation of high-speed of liquid drop – obstacle interaction: Cand.Sci. (Eng.) diss., author’s abstract.] St. Petersburg: SPbGTU, 1998, 18 p. (in Russian).

9. Chizhov, A.V., Schmidt, A.A. Vysokoskorostnoy udar kapli o pregradu. [Impact of a high-velocity drop on an obstacle.] Technical Physics, 2000, vol. 45, iss. 12, pp. 1529-1537 (in Russian).

10. Haller, K.K., et al. Computational study of high-speed liquid droplet impact. Journal of Applied Physics, 2002, vol. 92, no. 5, pp. 2821–2828.

11. Grigoryev, I.S., Meylikhov, E.Z., eds. Fizicheskie velichiny. Spravochnik. [Physical Quantities. Reference book. ] Moscow: Energoatomizdat, 1991, 1232 p. (in Russian).

12. Rid, R., J.M. Prausnitz, Sherwood, T. Svoystva gazov i zhidkostey. Spravochnoe posobie. [The properties of gases and liquids. Handbook.] Sokolov, B.I., ed. Trans. from Engl. Leningrad: Khimiya, 1982, 592 p. (in Russian).

13. Sushchinskiy, М.М. Spektry kombinatsionnogo rasseyaniya molekul i kristallov. [Spectra of Raman scattering of molecules and crystals.]. Moscow: Nauka, 1969, 300 p. (in Russian).

14. Demtroder, W. Lazernaya spektroskopiya: osnovnye printsipy i tekhnika eksperimenta. [Laser spectroscopy: basic principles and experimental technique.] Sobelman, I.I., ed., Trans. from Engl. Moscow: Nauka, 1985, 608 p. (in Russian).

15. Becker, J. Spektroskopiya. [Spectroscopy.] Kazantseva, L.N., Trans. from German; Pupysheva, A.A., Polyakova, M.V., eds. Moscow: Tekhnosfera, 2009, 528 p. (in Russian).

16. Smith, А. Prikladnaya IK-spektroskopiya: osnovy, tekhnika, analiticheskoe primenenie. [Applied IR-spectroscopy: basics, technique, and analytical application.] Tarasevich, B.N., Trans. from Engl.; Maltsev, A.A., ed. Moscow: Mir, 1982, 328 p. (in Russian).

17. Varavka, V.N., Kudryakov, O.V. Zakonomernosti iznosa stali pri vozdeystvii diskretnogo vodno-kapel'nogo potoka. Chast' 1. Nachal'naya stadiya kapleudarnoy erozii. [Regularities of steel wear under the impact of discreet waterdroplet stream. Part I: Initial stage of droplet-impingement erosion.] Journal of Friction and Wear, 2015. — vol. 36, iss. 1, pp. 71–79 (in Russian).

18. Varavka, V.N., Kudryakov, O.V. Zakonomernosti iznosa stali pri vozdeystvii diskretnogo vodno-kapel'nogo potoka. Chast' 2. Stadiya razvitoy kapleudarnoy erozii. [Regularities of steel wear under the impact of discreet water-droplet stream. Part II: Stage of the developed droplet-impingement erosion.] Journal of Friction and Wear, 2015, vol. 36, iss. 2, pp. 153-162 (in Russian).

19. Kudryakov, O.V., Varavka, V.N. Mekhanizmy i zakonomernosti degradatsii poverkhnosti stali na stadiyakh razvitoy kapleudarnoy erozii. [Mechanisms and laws of steel surface degradation during the stages of developed droplet erosion.] J. Surf. Invest.: X-Ray, Synchrotron Neutron Tech. 2015, vol. 9, iss. 1, pp. 203–214 (in Russian).


Review

For citations:


Kudryakov O.V., Varavka V.N., Irkha V.A., Moiseeva I.V. To problem of hydrogen embrittlement of steel at droplet impingement erosion. Vestnik of Don State Technical University. 2017;17(2):56-69. (In Russ.) https://doi.org/10.23947/1992-5980-2017-17-2-56-69

Views: 603


Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 License.


ISSN 2687-1653 (Online)